Scientists develop a new way to deliver drugs through the skin

Scientists develop new way to deliver more drugs through the skin
A prototype patent-pending temporal pressure device developed by the NTU and A*STAR scientists, which can put pressure on the skin, thus creating micropores that allow the drugs to pass through the skin easier. Credit: Nanyang Technological University

Scientists from Nanyang Technological University, Singapore (NTU Singapore) and the Agency for Science, Technology and Research (A*STAR) have shown that applying 'temporal pressure' to the skin of mice can create a new way to deliver drugs.

In a paper published in Science Advances, the researchers showed that bringing together two magnets so that they pinch and apply pressure to a fold of , led to short term changes in the skin barrier and specifically the formation of "micropores" underneath its surface.

In tests, they showed that these micropores, of about 3 micrometers in area, allowed drugs applied on the surface of the skin to diffuse through it more easily. Six times greater quantity of drug diffused through the skin of mice with the micropores compared to the skin of mice which did not receive the temporal pressure treatment.

Lead author of the paper, Dr. Daniel Lio, who did this research as part of his doctoral thesis at NTU's School of Chemical and Biomedical Engineering, Interdisciplinary Graduate Programme, said that while needles and microneedle injections damage the skin, micropores could pave the way towards painless transdermal delivery of drugs such as insulin.

"Our research project was first inspired by the traditional Chinese medicine 'tuina' therapy where physicians rub and apply pressure on skin and and apply a topical ointment," explained Dr. Lio, who is now working at A*STAR's Enterprise Group.

Going a step further, the joint team which included Prof David Laurence Becker from NTU Lee Kong Chian School of Medicine and Skin Research Institute of Singapore; Assoc Prof Wang Xiaomeng from the NTU Lee Kong Chian School of Medicine, and Assistant Prof Xu Chenjie from the School of Chemical and Biomedical Engineering, tested the delivery of insulin through the skin of mice using the new method.

Reducing skin damage and pain from delivering drugs through skin

Experimental results showed that nanoparticles and insulin were effectively delivered through the skin of mice, at molecular masses up to 20,000 daltons.

This mass is 40 times the largest currently reported in the scientific literature for transdermal drug delivery (i.e. via patches), which is 500 daltons.

The amount of drug delivered via the temporal pressure method was also comparable to the amount delivered by a microneedle patch—dozens of needles smaller than the width of a human hair made from biocompatible compounds, commonly used to deliver small amounts of drugs through the skin over time.

Compared to conventional injection where the skin has to be penetrated and there is a risk of a hypoglycaemia effect—when the injected insulin acts too fast and the patient gets dizzy—the new method is able to slowly deliver drugs over time without breaking the skin, thus causing less pain.

In experiments, the team also found that with their method, cells in the skin layer (epidermis) were observed to have an increase in the number of 'gap junctions' and a reduction in 'tight junctions.' These junctions control the amount of molecules being delivered between the cells: if there is an increased expression of gap junctions, more molecules can be delivered across the cell barrier, while tight junctions restrict the extracellular movement of molecules.

In the , two magnets were used to apply pressure on the mouse dorsal skin for one or five minutes, depending on how fast the drug delivery is needed, before being removed and the drug is then topically applied like a cream.

The team hypothesized that for drugs that need to be delivered more slowly or in smaller doses—1 minute would be sufficient, while for drugs to be delivered faster, more micropores would be needed, therefore five minutes would be required.

The drug was then left for 12 hours before the skin was imaged with fluorescent microscopy to see to what extent the drug had penetrated through the skin.

The team compared three types of skin: skin that received pressure treatment, skin which had not, and skin which had drugs delivered through microneedles.

Skin that received pressure treatment had similar amounts of drug delivered through the skin to that found with a microneedle patch, while skin that did not receive the pressure treatment had significantly less delivered.

Micropores were also observed to disappear a day after they were formed, which suggests that the skin cells have filled up the gaps.

Prof Becker, whose research expertise is in tissue repair and regeneration, said their paper highlighted the potential to use this method which could alleviate the need for diabetes patients to inject insulin multiple times daily using conventional needles and syringes.

"Patients who have to inject drugs daily, such as insulin, are constantly asking whether there is another way to deliver their medicines that doesn't involve hurting or penetrating the skin. Our new findings hold promise for them and we hope that we can refine this method so that one day it may be possible to deliver enough drugs through the skin via a patch and to rid them of their daily injections," Prof Becker added.

More information: Daniel Chin Shiuan Lio et al. Temporal pressure enhanced topical drug delivery through micropore formation, Science Advances (2020). DOI: 10.1126/sciadv.aaz6919

Journal information: Science Advances
Citation: Scientists develop a new way to deliver drugs through the skin (2020, August 4) retrieved 19 March 2024 from https://medicalxpress.com/news/2020-08-scientists-drugs-skin.html
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no part may be reproduced without the written permission. The content is provided for information purposes only.

Explore further

Microscopic STAR particles offer new potential treatment for skin diseases

292 shares

Feedback to editors